Product ID:ZEP BIG ORANGE #0415 INDUSTRIAL SOLVENT DEGREASER
MSDS Date:06/20/1994
FSC:7930
NIIN:01-412-0985
Status Code:A
MSDS Number: CLBTB

Emergency Phone: (800)424-9300

Cage: 27674

Telephone: 877-428-9937

Cage: 27674

D-LIMONENE

CAS: 5989-27-5

RTECS: GW6360000

NPE;

CAS: 9016-45-9

RTECS: AX0247000

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:PRODUCT CAN BE AN EYE IRRITANT.
INFLAMATION OF EYE TISSUE IS CHARACTERIZED BY REDNESS, WATERING,
AND/OR ITCHING. ONE OF THE INGREDIENTS IN THIS PRODUCT HAS CAUSED
SENSITIZATION REACTIONS IN A SMALL PE RCENTAGE OF THE GENERAL
POPULATION. PROLONGED CONTACT MAY CAUSE REDNESS, ITCHING, OR
BLISTERING OF THE SKIN.
Effects of Overexposure:MSDS DATA PERTAINS TO PRODUCT AS DISPENSED FROM
CONTAINER. ADVERSE HEALTH EFFECTS WOULD NOT BE EXPECTED UNDER
RECOMMENDED CONDITIONS OF USE (DILUTED) SO LONG AS PRESCRIBED
SAFETY CONDITIONS ARE PRACTI CED.

First Aid:SKIN: FLUSH WITH COPIOUS AMOUNTS OF WATER. WASH WITH SOAP OR
MILD DETERGENT. APPLY SKIN CREAM WITH LANOLIN. IF IRRITATION
PERSISTS, SEE DR. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES, OC CASIONALLY LIFTING UPPER AND LOWER LIDS. GET MEDUCAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. IF IRRITATION
PERSISTS, GET MED ATTENTION PROMPTLY. INGESTION: DRINK PLENTY OF
WATER. DO NOT INDUC E VOMITING. CALL DR.

Flash Point Method:TCC
Flash Point:=49.4C, 121.F
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:FIRE EXPOSED DRUMS SHOULD BE COOLED WITH
STREAM OF WATER.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:IMMEDIATELY ELIMINATE ALL FLAME, IGNITION, AND
HIGH HEAT SOURCES. ABSORB SPILL ON INERT, ABSORBANT MATERIAL
(ZEP-O-ZORB). PICK UP AND PLACE RESIDUE IN CLEAN, DOT SPECIFICATION
CONTAINER FOR DISPOSAL. WASH AREA THOROUGHLY WITH DETERGENT
SOLUTION, THEN RINSE WELL WITH WATER.

Handling and Storage Precautions:COMBUSTABLE! STORE AND USE AWAY FROM
HEAT, SPARKS, OPEN FLAME, OR ANY SOURCE OF IGNITION. POST "NO
SMOKING" SIGNS ACCORDING TO LOCAL REGULATIONS FOR COMBUSTABLE
LIQUIDS. KEEP AWAY FROM SKIN AND EYES. STORE TIGHTLY CLOSED
CONTAINER IN DRY AREA (40-120DEGREES F). KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:CONSULT LOCAL, STATE, OR FED AGENCIES FOR PROPER
DISPOSAL METHOD IN YOUR AREA. RCRA #D001.

Respiratory Protection:NO SPECIAL MEASURES ARE REQUIRED
Protective Gloves:NITRILE GLOVES OR GLOVES PROVEN TO BE RESISTANT TO
INGREDIENTS
Eye Protection:WEAR TIGHT-FITTING SAFETY GLASSES OR GOGGLES.
Supplemental Safety and Health

Spec Gravity:0.853
pH:7.6 DILUTE 1:20
Evaporation Rate & Reference:APPROX 33 CCL4=1
Solubility in Water:EMULCIFIES
Appearance and Odor:ORANGE LIQUID WITH A CITRUS ODOR.
Percent Volatiles by Volume:93.8

Stability Indicator/Materials to Avoid:YES
HEAT, FLAME, SPARKS, STRONG ACIDS, AND/OR OXIDERS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, AND
OTHER UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:LIQUIDS CANNOT BE SENT TO LANDFILLS UNLESS
SOLIDIFIED. UNUSABLE PRODUCT AND COLLECTED SPENT MATERIAL MAY
REQUIRE DISPOSAL AS A HAZARDOUS WASTE AT PERMITTED
TREATMENT/STORAGE/DISPOSAL FACILITY. SOLVENT WASTES MAY REQUIRE
TREATMENT TO MEET APPROPRIATE STANDARDS BEFORE DISPOSAL IN CHEMICAL
INDUSTRIAL W ASTE LANDFILL.

SARA Title III Information:ETHYLENE GLYCOL: CAS # 107211
State Regulatory Information:

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.